copper ore particle size

Home > Produts > >copper ore particle size

() Effect of Collector Types onto Copper Ore in

In this study, effects of different collector types (A-3418A, A-3477) and dosages (50-100-150 g/t) according to particle size variations is researched on Cayeli copper ore with 4.8% Cu, ground to

Investigation of Flotation Parameters for Copper Recovery

2012-3-22 · ore contained 0.32mass% As and 21.63mass% Cu. The two ore samples were mixed at 7 : 3 (enargite : chalcopyrite) by weight ratio to prepare a mixed ore sample with As content at 3.16 and 18.25mass% Cu for the flotation study. Effect of particle size, slurry pH, flotation time, collector

The effect of mineral grain textures at particle surfaces

2019-10-11 · that while particle size and perimeter composition affect particle flotation response the spatial arrangement of the copper mineral grains at the particle surface plays a key role. For the iron-oxide-copper-gold ore, copper mineral grains in complex texture classes

What is the maximum size of copper ore

What is the maximum size of copper ore. The production of concentrates implies the crushing and later milling of the ore down to a particle size allows releasing copper by flotation The concentrates from different regions have approximately between 24 up to 36 of copper Copper concentrates are then submitted to a final filtration and drying

Studying on Leaching Process of African Copper Oxide Ore

2019-9-12 · Studying on Leaching Process of African Copper Oxide Ore by Ammonium Carbonate Solution SONG Zhi-peng, HU Guo-rong, PENG Zhong-dong, ZHOU Yu-lin School of Metallurgical Science & Engineering, Central South University, Changsha 410083, Hunan

RECOVERY OF COPPER FROM OXIDE COPPER ORE BY …

2014-12-24 · RECOVERY OF COPPER FROM OXIDE COPPER ORE BY FLOTATION AND LEACHING Kiraz, Emirhan M.S., Department of Mining Engineering Supervisor: Prof. Dr. Mustafa Ümit Atalay December 2014, 65 pages The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching.

Investigating of the effect of ore work index and particle

2017-2-12 · surface methodology (RSM) for grinding modeling of some copper sulphide ores. In the present work, the effects of some key grinding parameters such as ball size (20–40mm), grinding time (10–30min), solids content (65–80%), and also ore work index (12–15.4kWh/t) on the grinding of some copper sulphide ore were investigated.

Determination of liberation size of Akiri copper ore

2014-4-30 · Determination of liberation size of Akiri copper ore, Nasarawa state, north-central Nigeria 1M.N.S. Usaini, 2Mohammed Ali, 3Hussaina Abubakar Usman Department of Mineral Resources Engineering, Kaduna Polytechnic, Kaduna _____ Abstract This research work focused on the Determination of Liberation Size of Akiri Copper Ore in Nasarawa state.

low-grade primary copper sulfide --cnki

To recover and utilize the low-grade primary copper sulfide ore resource in the waste ore in Yongping Copper Mine,the effect of inoculation concentration,initial Fe~(2+) concentration,ore particle size and pulp density on its bioleaching was studied.

Study on Correlation between Particle Size of Oxidized

The correlation between the particle size of oxidized copper ore and its metal extraction rate in heap leaching process was studied.The results showed that very good leaching effect was achieved in the heap leaching of this kind of oxidized copper ore when the liquid

Research on Reasonable Leaching Process of Yulong

The tests of the whole-grain column leaching and washing-sand column leaching-stirring leaching on the oxide copper ore from Yulong copper mine are carried out.The result showed that the whole-grain column leaching has a lower permeability,and easily resulted in

4 Leaching kinetics of low-grade copper ore with high-alka

2014-9-26 · 4 Leaching kinetics of low-grade copper ore with high-alka___ 20| 4 Leaching kinetics of low-grade copper ore with high-alka___。J.?Cent.?South?Univ. (2012) 19: 77?84?

The Effect of Solids Concentration, Flocculant Dosage and

2019-10-27 · were reduced with particle size. Furthermore, settling flux observed for the combination of particle size fractions and flocculant dosages such as +44-63 μm and 30 g/t, +63-88 μm and 20 g/t, +88-125 μm and 10 g/t was similar and about 2 t/m2h. It could be said that, the required flocculant dosage was increased with reducing particle size to

Investigation of Flotation Parameters for Copper Recovery

2012-3-22 · ore contained 0.32mass% As and 21.63mass% Cu. The two ore samples were mixed at 7 : 3 (enargite : chalcopyrite) by weight ratio to prepare a mixed ore sample with As content at 3.16 and 18.25mass% Cu for the flotation study. Effect of particle size, slurry pH, flotation time, collector

Open Access The Leaching of Dolomitic-Copper Ore …

2017-5-7 · Abstract: The leaching of dolomitic-copper ore using sulphuric acid under controlled conditions was studied with a view to evaluating the economic value and the effect of ore pulverisation, particle size, temperature and pH on the recovery of copper from chalcopyrite. The samples were ground and mixed with water and sulphuric acid to form an acid

The Effect of Sulfurization Process on Flotation of Copper

2013-12-24 · The effect of the parameters such as pH, pulp density, particle size and collector amount were investigated. KAX was used as collector and Dow-250 was used as frother. Key Words: Sulfurization, flotation, copper, gold, silver 1. INTRODUCTION Firstly, the copper ore containing gold and silver were ground, sieved to -160 mesh size,

Influence of feed particle size on upgrading selectivity

The lithological fractions differ in the particle-size distributions of their useful minerals. In the dolomitic part of the ore, most of the metal sulfide particles are 50–200 microns in size, while those in the sandstone and carbonaceous shale are 30–200 and 5–40 microns in size, respectively.

Study on Correlation between Particle Size of Oxidized

The correlation between the particle size of oxidized copper ore and its metal extraction rate in heap leaching process was studied.The results showed that very good leaching effect was achieved in the heap leaching of this kind of oxidized copper ore when the liquid

Effects of ore particle sizes on leaching regularities of

Ore particle size is an important factor that affects the copper leaching rates of secondary copper sulfide. To investigate the influence of ore particle size on the secondary copper sulfide ore

Effect of Particle Size on the Column Bioleaching of …

This study aimed to investigate the effect of ore particle size on the bioleaching of Yulong copper ore in the bench-scale columns using the mixed culture of moderately thermophilic microorganisms. Bioleaching experiments were carried out on particle sizes of 5-10, 10-15 and 15-25mm in the same kind of column reactors. In the control test of acid leaching, the column reactor was charged with

Open Access The Leaching of Dolomitic-Copper Ore …

2017-5-7 · Abstract: The leaching of dolomitic-copper ore using sulphuric acid under controlled conditions was studied with a view to evaluating the economic value and the effect of ore pulverisation, particle size, temperature and pH on the recovery of copper from chalcopyrite. The samples were ground and mixed with water and sulphuric acid to form an acid

4 Leaching kinetics of low-grade copper ore with high-alka

2014-9-26 · 4 Leaching kinetics of low-grade copper ore with high-alka___ 20| 4 Leaching kinetics of low-grade copper ore with high-alka___。J.?Cent.?South?Univ. (2012) 19: 77?84?

Comparative Analysis of the Strength Distribution for

2018-1-24 · lithological types of copper ore (carbonate, sandstone, and shale ore) were manually divided within each particle size fraction (Figure 1). Figure 1. The lithological types of copper ore within the particle size fraction. 2.1. Material Characteristic Selected physical and mechanical characteristics of the materials were determined. The results

Froth flotation

2019-10-9 · Froth flotation is a process for selectively separating hydrophobic materials from hydrophilic. This is used in mineral processing, paper recycling and waste-water treatment industries. Historically this was first used in the mining industry, where it was one of the great enabling technologies of the 20th century. It has been described as "the

Grain Size Comparisons

2019-10-17 · Grain Size Comparisons. NOTE: The file size of the Larger and Largest View of the Micrographs are substantially larger than the thumbnail shown.The Larger View images range in size from 11K to 120K depending on the image.The Largest View images range in size …